[Federal Register: August 10, 1995 (Volume 60, Number 154)]
[Proposed Rules]
[Page 40785-40792]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
=======================================================================
-----------------------------------------------------------------------
CONSUMER PRODUCT SAFETY COMMISSION
16 CFR Part 1500
Requirements for Labeling of Retail Containers of Charcoal;
Proposed Amendments
AGENCY: Consumer Product Safety Commission.
ACTION: Proposed rule.\1\
\1\ The Commission voted 2-1 to propose this rule. Chairman Ann
Brown and Commissioner Thomas H. Moore voted for the proposal;
Commissioner Mary Sheila Gall voted against the proposal. Separate
statements by each commissioner are available from the Office of the
Secretary.
---------------------------------------------------------------------------
-----------------------------------------------------------------------
SUMMARY: Under the Federal Hazardous Substances Act, the Commission is
proposing a rule to change the required labeling for retail containers
of charcoal intended for cooking or heating. The labeling addresses the
carbon monoxide hazard associated with burning charcoal in confined
spaces. The proposed amendments, which include a pictogram, are
intended to make the label more noticeable and more easily read and
understood and to increase the label's ability to motivate consumers to
avoid burning charcoal in homes, tents, or vehicles.
DATES: Comments on the proposal should be submitted no later than
October 24, 1995.
ADDRESSES: Comments should be mailed to the Office of the Secretary,
Consumer Product Safety Commission, Washington, D.C. 20207, or
delivered to the Office of the Secretary, Consumer Product Safety
Commission, room 502, 4330 East-West Highway, Bethesda, Maryland 20814-
4408, telephone (301) 504-0800.
FOR FURTHER INFORMATION CONTACT: Sharon White, Project Manager,
Division of Human Factors, Directorate for Engineering Sciences,
Consumer Product Safety Commission, Washington, D.C. 20207; telephone
(301) 504-0468 ext. 1286.
SUPPLEMENTARY INFORMATION:
A. Background
1. Relevant Statutes and Regulations. Since its creation in 1973,
the Consumer Product Safety Commission (``Commission'' or ``CPSC'') has
administered the Federal Hazardous Substances Act (``FHSA''), 15 U.S.C.
1261-1278. Prior to that time, the FHSA was administered by the Food
and Drug Administration (``FDA'').
The FHSA defines ``hazardous substance'' as including any
``substance or mixture of substances which (i) is toxic * * * if [it]
may cause substantial personal injury or substantial illness during or
as a proximate result of any customary or reasonably foreseeable
handling or use. * * *'' Section 2(f)(1)(A) of the FHSA, 15 U.S.C.
1261(f)(1)(A). Hazardous substances are misbranded if they do not bear
the labeling required by section 2(p)(1) of the FHSA, 15 U.S.C.
1261(p)(1).
Section 3(b) of the FHSA, 15 U.S.C. 1262(b), authorizes the
Commission to issue regulations establishing variations from or
additions to the labeling required under section 2(p)(1) if the
Commission finds that the requirements of section 2(p)(1) are not
adequate for the protection of the public health and safety in view of
the special hazard presented by any particular hazardous substance.
Rulemaking under section 3(b) is conducted under the informal notice
and comment procedure provided in 5 U.S.C. 553.
In addition, section 3(a) of the FHSA, 15 U.S.C. 1262(a),
authorizes the Commission to issue regulations declaring products to be
hazardous substances if the Commission finds they meet the definition
of hazardous substance in section 2(f)(1)(A). The purpose of this
authority is to avoid or resolve uncertainty as to the application of
the FHSA. 15 U.S.C. 1262(a).
In 1970, the FDA proposed a rule under sections 3(a) and 3(b) of
the FHSA to require a statement on packages of charcoal intended for
household use that would warn of the potentially deadly hazard of
carbon monoxide (``CO'') poisoning from breathing the combustion
products of charcoal when used in a confined area. 35 FR 13887
(September 2, 1970). In 1971, FDA issued a final rule that is currently
codified in 16 CFR 1500.14(b)(6). That section requires the following
borderlined label on containers of charcoal for retail sale and
intended for cooking or heating:
BILLING CODE 6355-01-P
[[Page 40786]]
TP10AU95.112
BILLING CODE 6355-01-C
The current label is required to appear on both the front and back
panels of bags of charcoal, in the upper 25% of the panels, at least 2
inches below the seam, at least 1 inch above any other reading material
or design element of the bag, and in specified minimum type sizes.
2. Nature of the hazard. [6, Tab B] 2 CO is produced by the
incomplete combustion of fuels such as charcoal. The level of CO
produced from burning charcoal may accumulate to toxic levels in closed
environments. CO is a colorless, odorless gas which reduces the blood's
ability to carry oxygen by reacting with hemoglobin to form
carboxyhemoglobin (COHb). The symptoms of CO poisoning range from
nausea to death. Each individual's reaction to CO exposure varies,
depending on several factors including age, health status, or smoking
habits. Due to the nonspecific nature of the symptoms that can be
associated with CO poisoning (e.g., fatigue, lethargy, dizziness, or
diarrhea), misdiagnoses of both acute and chronic CO poisonings can be
expected. Additionally, CO is odorless, which may contribute to
individuals frequently being unaware of their exposure to CO.
\2\ Numbers in brackets indicate the number of a document as
listed in the List of Relevant Documents in Appendix 1 to this
notice.
---------------------------------------------------------------------------
3. Petition from Barbara Mauk. On October 12, 1990, CPSC received a
letter from Barbara Mauk petitioning the Commission to amend the
current label on bags of charcoal. [1] In this letter, the petitioner
cited an incident that occurred when she and her son were camping 1
year previously. After grilling food outside her camper and before
retiring for the night, she brought the grill inside the camper. She
assumed that the charcoal was extinguished, even though the grill was
still warm. Two days after the incident, she and her son were found.
Her son died from CO poisoning, and she was hospitalized and treated
for CO poisoning. Ms. Mauk stated that she knew that CO has no odor and
can be lethal, but she did not know that charcoal can produce CO. She
stated that had she known this, she would have taken the precaution of
making sure the coals were out or left the grill outside. The petition
(No. HP 91-1) requested that the current label on bags of charcoal be
revised to state that: (1) Charcoal produces CO (and if applicable,
other lethal or toxic fumes), (2) charcoal produces fumes until the
charcoal is extinguished, and (3) CO has no odor.
On December 22, 1992, the Commission voted to grant the petition as
to the statements that charcoal produces CO and that CO has no odor,
and deny the petition as to adding statements that charcoal produces
these fumes until the charcoal is completely extinguished. [2] The
Commission also voted to improve the label's precautionary language,
specifically with reference to ventilation.
4. Subsequent actions by the Commission. In 1993, the Commission's
staff became aware of data that indicated that a pictogram is needed to
communicate the safety message to those who do not read English. [6,
Tab E(1)] Further, an article, discussed below in section B of this
notice, reported that 73% of the victims in one area over an 11-year
period were members of ethnic minorities, many of whom were Hispanic or
Asian immigrants who could not speak English. [3]
On April 22, 1994, the staff met with industry to present staff's
recommendations for revising the warning label on packages of charcoal.
Industry indicated a willingness to revise the warning label, but
raised a number of concerns. These concerns were considered
in developing the label.
On June 1, 1994, the Commission directed the staff to prepare, for
the Commission's consideration, a draft notice of proposed rulemaking
(``NPR'') to amend the labeling currently required for packages of
charcoal to warn of the dangers of burning charcoal indoors. The
proposed label would: (1) Clarify the dangers of burning charcoal
indoors; (2) remove the possibly misleading statement that implies that
charcoal can be safely burned indoors with ``ventilation;'' (3) add
color to the signal word panel; (4) include a pictogram, if feasible;
(5) include a Spanish safety message if a pictogram is not feasible;
and (6) include additional features recommended by the staff to make
the safety messages more conspicuous and understandable.
On April 13, 1995, staff met with industry again to present the
results of the pictogram tests and staff's current recommendations for
revising the warning label on packages of charcoal. [6, Tab F] The
changes to the recommended warning label reflected, for the most part,
concerns industry representatives raised at the April 1994 meeting.
After considering the additional comments received at the April 1995
meeting, the staff recommended a label to the Commission. The staff
also described possible variations of that label for the Commission's
consideration. The label the Commission decided to propose, and the
reasons the various features of the label were chosen, are described in
section D of this notice.
B. CO Poisoning Incidents
The Commission's Division of Hazard Analysis examined available
data concerning CO poisoning incidents. [6, Tab C] That Division
estimates that there was an average of about 26 non-fire CO-related
deaths per year associated with charcoal grills and hibachis from 1986
to 1991.3 (The annual estimate of non-fire CO deaths fluctuates,
with no discernible pattern.) Data from the CPSC's National Electronic
Injury Surveillance System (``NEISS'') indicate that there was an
average of about 400 emergency-room-treated injuries involving charcoal
grills and hibachis annually from 1980 to 1993.
\3\ As noted above, CO is produced as a product of incomplete
combustion. The term ``non-fire'' means that the CO was not produced
as the result of a conflagration or other unintended open flame.
---------------------------------------------------------------------------
Hazard Analysis staff reviewed 103 incident reports involving CO
deaths and injuries associated with charcoal for the years 1986 to
1994. There were 164 victims reported in the incidents: 111 died and 53
recovered. Most of the victims were males who were exposed to CO while
sleeping. Eighty-seven of the 164 victims were members of ethnic
minorities, and slightly more than half of these were reported to be
Hispanic. The data provide some indication that many of the Hispanic
victims, particularly those who were foreign-born, were of a low
socioeconomic status. The English language literacy for most of these
victims was not reported. However, three reports indicated that a
Spanish translator was present during the investigation. Information
about the victims' awareness of the potential for CO poisoning from
burning charcoal indoors was not available for most of the incidents.
More than half (65) of the incidents involved a charcoal barbecue
grill or hibachi. Information on the safety labeling on the packages of
the charcoal involved in most of these incidents was not available.
However, the Commission's Office of Compliance has no record of opening
a case based on a violation of the charcoal special labeling
[[Page 40787]]
requirement, and there is no reason to believe that the packages of
charcoal involved in these incidents did not bear labels warning of the
CO hazard.
Half of the incidents occurred when the victims burned charcoal in
their homes or in areas being used for living purposes. There were 52
cases where it was reported that victims used charcoal to keep warm. In
nine incidents, there was an indication of an attempt to provide some
ventilation. Most of the incidents occurred during the fall and winter.
An article prepared by Hampson, N.B. et al. (1994), reports that 79
victims were treated for CO poisoning resulting from burning charcoal
indoors in the Seattle, Washington, area between October 1982 and
October 1993. [3] Fifty-eight (73%) of the victims were members of
ethnic minorities, many of whom were Hispanic or Asian immigrants who
could not speak English. There was no information available, however,
documenting whether they could read English.
C. The Pictogram
The CPSC staff, a charcoal manufacturer, and Dr. Neil B. Hampson of
Washington State each developed a pictogram. [6, Tab E(2)] Each
pictogram was tested according to ANSI Z535.3, American National
Standard for Criteria for Safety Symbols.
The pictogram developed by CPSC staff obtained the highest
percentage of correct responses in the first round of testing. This
pictogram achieved 56% correct responses, with 4% critical confusion.
(Critical confusion is where the message conveyed contradicts the
intended message.)
Based on findings from the test results, the three pictograms were
revised and presented for a second round of testing. The revised
pictogram developed by a charcoal manufacturer obtained the highest
percentage of correct responses in this round of testing (74% correct
responses, with no critical confusion).
The ANSI Z535.3 test method recommends that, to be selected, a
pictogram should obtain 85% correct responses with a maximum of 5%
critical confusion. In this case, however, the staff believes that, for
the following reasons, it is appropriate to use the pictogram that
scored highest :
1. Stringent criteria were used to select the subjects, which helps
to assure a rigorous test. Fifty subjects were tested (50% Hispanics
who did not read English and were at or below the poverty level, and
50% people who do read English and were below the median income). No
middle or upper income people were included in the test.
2. Had the pictogram been tested in context (i.e., on bags of
charcoal), the 85% level might have been attained.
3. The 74% correct responses for the pictogram chosen does not
differ greatly from the 85% ANSI criterion. Furthermore, the tested
pictogram had no critical confusion in the responses, while ANSI allows
5%. This is significant because a person who believed that the
pictogram meant that it was appropriate to burn charcoal indoors could
be more likely to do so.
Staff previously recommended that if the pictograms did not
adequately communicate the safety message, the safety message should be
presented in both English and Spanish. As discussed above, the
Commission concludes that the pictogram does adequately convey the
message. However, according to the contractor who administered the
test, a clinical psychologist who regularly works with low-income
Hispanics, many in the target population are unable to read either
English or Spanish. [6, Tab E(2)] Therefore, a safety message in
Spanish instead of a pictogram would not necessarily reach those
Hispanics who do not read English.
Additionally, while the largest single group of minority victims
identified in the CPSC data is Hispanic, others, most notably Asian
immigrants who do not read English or Spanish, would not be informed by
a label in Spanish.
Accordingly, a pictogram appears to be the most effective measure
to address those who do not read English. The Commission does not
believe that a label that combines both English and Spanish warning
statements with a pictogram is warranted. For the reasons discussed
above, the Commission cannot conclude in this case that such a label
would be significantly more effective than one combining a pictogram
and a warning statement in English. Furthermore, including both
languages and a pictogram on the label would increase the size of the
label, with potential adverse economic effects on the industry. See the
discussion of label size below in section E of this notice.
A charcoal grill manufacturer objected to some features in the
depiction of the grill in the pictograms that were tested. [7] The
manufacturer stated that the depiction of a grill with three legs and a
semi-ellipsoid shaped kettle, as in the tested pictogram, violated
registered trademarks of its brand of grill. The Commission's Human
Factors staff concluded that a pictogram that depicted a grill with
four legs and a shallower shape of the kettle would communicate the
idea of a charcoal grill at least as well as the tested version.
Accordingly, the proposed pictogram differs from the most successful
one tested in those regards. The fact that the Commission is proposing
these changes from the tested pictogram should not be interpreted as an
opinion on the validity of the relevant trademarks or as a waiver of
any right in the nature of ``fair use'' that the Government may have to
use a trademark without authorization.
During the development of the proposed label, the Commission's
staff discussed with industry whether the pictogram should appear above
or to the side of the warning statement. Industry noted that allowing
the pictogram to be beside the warning statement would reduce the
vertical height of the revised label. As discussed below, increasing
the minimum allowed height of the label can have an adverse economic
effect on producers of bags for charcoal. The Commission's staff also
concluded that placing the pictogram to the left of the warning
statement will make the label more appealing visually and thus more
effective. Accordingly, the Commission is proposing to require the
pictogram to be adjacent to, and to the left of, the warning statement.
D. The Warning Statement
The Commission proposes that the revised label should explicitly
state: ``CARBON MONOXIDE HAZARD--Burning charcoal indoors can kill you.
It gives off carbon monoxide, which has no odor. NEVER burn charcoal
inside homes, vehicles, or tents.'' The rationale for the revisions to
the label is discussed briefly below .
Statement of Hazard. To motivate consumers to comply with the
label, it is important that the label explicitly state the hazard,
i.e., that burning charcoal indoors can kill due to the production of
CO. Thus, the label states ``CARBON MONOXIDE HAZARD.''
An early draft of the label used the term ``CARBON MONOXIDE
POISONING.'' This was changed because industry claimed that the term
could be interpreted by some consumers as inaccurately warning that
charcoal cooking could poison food.
Statement of Consequences. The phrase ``cause death'' in the
current label should be replaced by the more personal phrase ``can kill
you.'' Research indicates that personalizing the warning will make it
difficult for users to conclude that the warning is not directed at
them and, therefore, that it is not important to comply with the
warning.
[[Page 40788]]
Statement of How to Avoid Hazard. The label should clearly state
the action to be taken or avoided. Thus, the label should be revised to
state ``NEVER burn charcoal inside homes, vehicles, or tents.'' The
current statement, ``Do Not Use for Indoor Heating or Cooking Unless
Ventilation Is Provided for Exhausting Fumes to Outside,'' may be
dangerously misleading. It may incorrectly convey to the user that it
is safe to burn charcoal indoors if some sort of ventilation is
provided. Even if charcoal is burned in areas where there is some
ventilation, CO may not be reduced to safe levels.
An industry member stated that advising users that they should
never burn charcoal indoors was unnecessary and too stringent. He cited
the example of restaurants, and some home owners, that cook indoors
with charcoal under a hood with ducting and a high-capacity exhaust fan
to expel the CO to the outside. He also expressed the fear that
changing the wording of the label would make users think there had been
some change in the product that made it more dangerous.
The Commission does not believe that persons who have gone to the
trouble and expense of installing a powered exhaust hood specifically
so they can cook indoors with charcoal are going to think the label
applies to them (except to the extent they should be sure the exhaust
system is operating properly). The Commission concludes that including
language on the label to indicate that charcoal can be burned indoors
if such an exhaust system is used would dilute the primary safety
message and confuse consumers who did not have such a system.
Marketers of charcoal may provide additional explanatory material
about the statement to never use charcoal in homes. And, the label
statement could even be asterisked or footnoted to draw attention to
such material. However, such explanatory material must not negate the
content of the warning for persons without such specialized equipment.
To do so would violate the prohibition against deceptive disclaimers at
16 CFR 1500.122. In addition, packages of charcoal that are supplied
only to restaurants and other commercial establishments are not
required to comply with the FHSA, and are not subject to the
requirements for either the current label or the proposed revised
label.
This industry member also stated that it was safe to burn charcoal
in a fireplace that has a chimney with an open flue. However, the
Commission has information indicating that burning charcoal in a
fireplace may not create a chimney draft sufficient to exhaust CO to
the outside. [11] Accordingly, based on the presently available
information, the Commission concludes that including a statement that
charcoal can be burned in fireplaces would constitute a prohibited
deceptive disclaimer. The Commission seeks comment on this issue,
including specific data on whether, and under what conditions, charcoal
can safely be burned in a fireplace.
Recommended Revised Label. For the reasons stated above, and
elsewhere in this notice, the Commission proposes that the label
currently required on packages of charcoal be revised to appear and
read as follows:
BILLING CODE 6355-01-P
TP10AU95.113
BILLING CODE 6355-01-C
E. Other Features of the Label
Conspicuousness of the Safety Messages. The Commission's Human
Factors staff concluded that, as a matter of optimum label design, it
would be desirable for the label to be consistent with the ANSI Z535.4,
American National Standard for Product Safety Signs and Labels. That
standard specifies that the signal word ``WARNING'' should be written
in black lettering surrounded by an orange background. The signal word
should also be placed at the top of the label and be preceded by the
hazard alert symbol.
Under the ANSI standard for safety labels, the label should also be
surrounded by a black borderline, which in turn should be surrounded by
a white border to make the label more distinct. The Human Factors staff
also recommended that the lettering of the warning statement be in
black on a white background, to maximize readability. In addition, they
recommended that the ``X'' on the pictogram be red, to achieve the
maximum visual impact and warning effect.
The charcoal-bag industry, however, pointed out that this optimum
label would require the bag to have a minimum of four colors: red,
orange, black, and white. The industry stated that many of the printing
presses for charcoal bags have the capability of printing only six
colors, and that presses capable of printing more than six colors are
very expensive. Generally, most bags already have at least six colors,
and the presently-used colors often do not include one or more of the
colors that would be required by the ``optimum'' label described above.
Industry members stated that customers may consider the color scheme of
a product to be part of its brand identification. For the reasons given
by the industry, the Commission is proposing to not use the
[[Page 40789]]
colors specified by ANSI and described above. Thus, the proposed label
will not change the present requirement that the label shall be in a
``color sharply contrasting with the background'' and that the
borderline shall be ``heavy.'' Examples of color combinations that the
Commission's staff considers to be sharply contrasting, in order of
expected visual efficiency, are: black on white; black on yellow; white
on black; dark blue on white; white on dark red, green, or brown; black
on orange; dark green and red on white; white on dark gray; and black
on light gray. [9] Examples of colors that may not be considered
sharply contrasting are: black on dark blue or dark green, dark red on
light red, light red on reflective silver, and white on light gray or
tan. See 16 CFR 1500.121(d).
Processing Safety Messages. To make the label easier to read and
understand, the Commission proposes that the messages be presented
concisely and in an outline form, be presented in a horizontal format,
be left-justified with a ragged right margin, be in upper and lower
case lettering, be in the appropriate point-type, have an acceptable
strokewidth-to-height ratio, and have sufficient space between lines of
text.
Type Size. The Commission's Human Factors staff determined that in
order for the label's type to be legible and conspicuous, 18-point type
would be required. Thus, the proposed revision specifies
18-point type (3/16 inches) as the minimum allowable type size for the
safety messages. The signal word shall be in at least 27-point type (9/
32 inches).
Label Size. When the minimum specified type sizes are laid out in
the configuration specified in the proposed revised label, the label is
2 inches high. Accordingly, this is the minimum allowable height of the
label, and this size is suitable for the smallest-size bags of charcoal
presently marketed (2.5 lb.).
An industry member raised the question of whether the label can or
should be proportionately larger for larger-size bags. The Commission
recommends that larger bags use larger labels to the extent feasible.
The Commission solicits comment on whether it should, in the final
rule, require that labels be proportionately larger for larger bags. If
the Commission requires proportionately larger labels, it could require
larger type sizes for specified ranges of the area of the front and
back panels of the package. Comment is solicited on the appropriate
parameters and on the potential economic effects of larger labels on
larger bags.
The proposed revised label is taller than the currently required
label. The current label is required to be at least 2 inches from the
top seam. In order to maintain this required distance, the bottom edge
of a taller label would have to be lower on the bag. This could
interfere with existing graphics, which would then have to be
redesigned. This could require additional modifications to printing
plates and increase the cost of the proposed label revision, without
providing any identifiable safety benefit. Therefore, the Commission is
proposing to change the minimum allowable distance from the top seam to
the label from 2 inches to 1 inch. This would allow the taller label to
be printed without affecting other printing lower on the bag.
The Commission proposes to retain the current requirements that the
label must be on both the front and back panels of the bag and in the
upper 25% of the panels.
F. Economic and Product Information [6, Tab G]
Charcoal is a solid carbon material made from wood subjected to
extremely high temperature. It is available in lump, briquet and
powdered forms. To produce charcoal briquets, charcoal is ground, mixed
with other ingredients, and pressed into pillow shapes. Lump and
briquet charcoal is used as a fuel in cooking and in specialized
scientific, industrial and horticultural applications. Recreational
cooking consumes approximately 80-90% of charcoal production.
Specialized uses account for the remainder of charcoal consumption.
Nearly 800,000 tons of charcoal briquets were sold in 1992.
Charcoal briquet sales doubled between 1967 and 1977, were relatively
flat during the 1980's, and have shown a slight rise since 1991. The
popularity of gas grills may explain the flattening of sales during the
1980's. Charcoal briquet sales account for approximately 80-90% of the
annual production of charcoal. Imports comprise less than 1% of the
domestic sales of charcoal.
Supermarkets and hardware, discount, drug, and garden supply stores
sell charcoal to consumers in a variety of types and packages. Three
major types of charcoal briquets are available. One is the standard
briquet. Another is the ``instant-light'' briquet, which is impregnated
with a flammable substance. The third is a ``flavor additive'' briquet
which is produced with an aromatic wood such as hickory or mesquite.
Standard briquets generally are sold in multi-walled (multi-layered) 5,
10, 20 and 40-pound paper bags. The instant-light briquets are
available in similar 2\1/2\, 4, 5, 8, and 15-pound bags. Briquets are
also available in single use, wax impregnated, ``light-the-bag''
packages. Lump charcoal, which is pure charcoal, is marketed as a
natural product and is available in packaging similar to briquets.
Charcoal also may be sold in other sizes of bags or in corrugated boxes
depending upon marketing considerations. Based on an informal study of
the Washington, D.C. area market, the retail price of charcoal ranges
from approximately $.25 to $.75 per pound depending on package size,
although the retail price of some specialty charcoal may be higher.
Approximately 10 companies manufacture lump and briquet charcoal in
the United States. Several companies import charcoal. According to
industry representatives, the top five domestic charcoal manufacturers
control an estimated 90-95% of the market, with the leading company
controlling approximately 50%. Manufacturers provide lump charcoal and
charcoal briquets under an estimated 150 different brand names, most of
which are private or ``store'' brands. Relatively few are nationally or
regionally marketed brands.
An estimated 47.5 million households own charcoal grills. Based on
a survey conducted by the Barbecue Industry Association, the number of
``barbecuing events'' more than doubled over a 10-year period, with an
estimated 2.3 billion occurrences in 1991. [5] Based on ownership and
usage data obtained through this survey, an estimated 800 million of
these barbecuing events used charcoal. These data indicate that there
was an estimated average of 17 charcoal barbecuing events per year per
household that owned a charcoal grill. It is also estimated that, on
average, each of these households uses the equivalent of 3.4 10-pound
bags of charcoal per year.
There are approximately 26 deaths and 400 CO-related emergency
room-treated injuries associated with the use of charcoal each year.
Thus, there was approximately one death for every 1.8 million
households owning charcoal grills and one CO injury for every 118,750
households owning charcoal grills. Additionally, there were an
estimated 160 million bags of charcoal briquets sold in 1992. Thus,
there was approximately one death for every 6.2 million charcoal
briquet bags (0.16 deaths per million bags) and one CO injury for every
0.4 million bags (2.5 injuries per million bags).
The Commission estimates that changing the labeling requirements
for packages of charcoal has the potential
[[Page 40790]]
for substantial benefits to society. Based on the CPSC's injury cost
model, the average annual societal cost of an injury from charcoal-
related CO poisoning is approximately $10,000. The annual societal cost
of these injuries is approximately $4 million, given the estimated 400
such injuries per year. Additionally, there are an estimated 26 deaths
per year from charcoal-related CO poisonings. Assuming a statistical
value of life of $5 million, these injuries and deaths cost society
about $134 million annually. The avoidance of these injuries and deaths
represents the maximum potential benefits to society.
The costs to industry of revising the warning label include one-
time, start-up expenses and continuous, ongoing expenses. Start-up
expenses include the cost of new printing equipment and printing
plates, artwork, and negatives. Ongoing expenses relate to the
additional color requirements of the recommended warning label.
If the Commission were to mandate the ``optimum'' warning label
described above, which includes the additional color requirements,
industry representatives have indicated that aggregate start-up
expenses for the label could amount to as much as $6 million. Further,
the ongoing costs for added colors may be around $4 million per year.
If the start-up expenses are amortized over a 5-year period, the costs
of the revisions to the warning label may amount to about $5.2 million
annually.
However, the Commission is proposing to ease the requirements for
the placement of the label on bags of charcoal and to not mandate
additional colors. The costs of the proposed revision are estimated to
be no more than $1 million in start-up expenses. Easing the recommended
color requirements will allow continued use of current printing
equipment. Since the revised labeling rule is proposed to have an
effective date 12 to 18 months after publication of the final rule, no
additional burden to industry should result. This time should allow
firms to use up existing inventories of printed bags. If any preprinted
bags remain unfilled at that time, the costs of not using these bags
and of discarding them are not expected to be significant.
Benefits to society from the new label would exceed costs at 1%
effectiveness if, as proposed, additional colors are not required and
the current label position requirements are eased. If the label was
required to contain the four specified colors and the position
requirements of the label were not eased, as in the ``optimum'' label
described above, the label would need to be about 4% effective in order
for benefits to exceed costs.
G. Effective Date
The rule applies only to filled containers of charcoal. Marketers
of charcoal, however, have indicated that it is not unusual to have an
inventory of printed bags that would take 1 or 2 years to use up. These
marketers would prefer that the revised requirement relate to the date
the bag or other container was printed, so that all existing
inventories could be used. This approach would be impractical for the
Commission to enforce, however, since the staff would have to determine
not only when the bag of charcoal was filled, but when the bag was
printed. Accordingly, the Commission has decided to specify that the
rule applies to all containers of subject charcoal that are filled on
or after the effective date.
In order to address the marketers' concern about inventories,
however, the Commission proposes that the revised rule will not become
effective until sufficient time has passed for the industry to use up
most of its current inventory of printed bags. The Commission estimates
that this will occur on a date that is 12 to 18 months after the
issuance of a final rule. This will provide time to revise the plates
needed to print the new label, revise any other plates that may be
affected on the bag, conduct consumer acceptance tests if needed, print
new bags, and incorporate the new bags into production. It will also
provide time for existing inventories of printed bags to be depleted.
Of course, manufacturers who order additional printing of bags between
now and the effective date of the rule should limit the quantities
ordered so that large numbers of bags will not have to be discarded or
stickered with the new label. Accordingly, the Commission proposes that
the effective date will be at least 12, but not more than 18, months
after any final rule is published.
Although there can be no guarantee that any final rule will be the
same as the proposed rule, some manufacturers may wish to voluntarily
use the revised label before the effective date of a final rule. For
such firms, the Commission will, until further notice published in the
Federal Register, consider labels complying with the proposal as
complying with the current requirements of 16 CFR 1500.14(b)(6), as
well as with any revised requirements of this section, provided that
such labels are brought into full compliance with the final rule as
supplies are exhausted.
H. Regulatory Flexibility Act Certification
When an agency undertakes a rulemaking proceeding, the Regulatory
Flexibility Act, 5 U.S.C. 601 et seq., generally requires the agency to
prepare proposed and final regulatory flexibility analyses describing
the impact of the rule on small businesses and other small entities.
The purpose of the Regulatory Flexibility Act, as stated in section
2(b) (5 U.S.C. 602 note), is to require agencies, consistent with their
objectives, to fit the requirements of regulations to the scale of the
businesses, organizations, and governmental jurisdictions subject to
the regulations. Section 605 of the Act provides that an agency is not
required to prepare a regulatory flexibility analysis if the head of an
agency certifies that the rule will not have a significant economic
impact on a substantial number of small entities.
The Commission's Directorate for Economic analysis examined the
potential effects of the proposed rule on small entities. [6, Tab G]
Businesses affected by label-change costs may include charcoal
manufacturers (approximately 10 firms), bag suppliers, and firms that
own a charcoal brand name (proprietary or private label brands).
Industry representatives predict that the bulk of the costs of
developing new labels will fall initially on the charcoal
manufacturers. As noted above, these costs may include those associated
with the development or purchase of new printing plates, printing
equipment, artwork, and negatives.
Several private label manufacturers have indicated that they will
be disproportionately affected by a label change. These firms package
charcoal under a large number of brand names, which may require
hundreds of plate changes. According to information currently
available, the number of small firms that may be disproportionately
affected by a label change is not substantial, as only a few small
firms may fall into this category. Easing of the margin and color
requirements, as proposed, will substantially reduce these firms'
costs. These effects may be further mitigated if the firms are able to
pass costs through to their customers or if their plates are near the
end of their service life. Costs for other small firms are not expected
to be significant, due to the relatively small number of brands and
sizes handled by such firms.
The rule should not require small firms to buy new printing
presses. Manufacturers would be given enough time to use up existing
supplies of printed bags. Bags filled with charcoal
[[Page 40791]]
before the effective date are not subject to the revised requirements.
Accordingly, for the reasons given above, the Commission
preliminarily certifies that the proposed rule, if issued, would not
have significant economic effects on a substantial number of small
entities. However, the Commission solicits comments concerning the
potential effects of the proposed rule on small firms.
I. Environmental Considerations
Pursuant to the National Environmental Policy Act, and in
accordance with the Council on Environmental Quality regulations and
CPSC procedures for environmental review, the Commission has assessed
the possible environmental effects associated with the proposed rule to
revise the warning labels for packages of charcoal. Preliminary
analysis of the potential impact of this proposed rule indicates that
it would have no significant effects on the environment if the
effective date of a rule enables the firms to deplete existing stocks
of filled and empty bags. (Some firms have indicated that, depending on
the time of the year, they may have as much as a 2-year supply of
filled and empty bags.) As previously noted, bags filled before the
effective date would not be affected by the proposed rule. Even if some
old inventory of bags remains and cannot be restickered, the
environmental consequences would not be major.
Therefore, because the proposed rule would have no significant
impact on the environment, neither an environmental assessment nor an
environmental impact statement is required.
J. Conclusion
For the reasons discussed above, the Commission preliminarily
concludes that the labeling required by section 2(p)(1) of the FHSA for
packages of charcoal is not adequate for the protection of the public
health and safety, in view of the special hazard of CO poisoning
presented by using charcoal in a confined area. The Commission
preliminarily finds that the additional label requirements in the
proposed revised label are necessary for the protection of the public
health and safety and proposes to issue such requirements under the
authority of section 3(b) of the FHSA, 15 U.S.C. 1262(b).
Effective Date
The Commission proposes to make the final rule effective on a date
that is 12 to 18 months after it is published in the Federal Register,
as to charcoal intended for cooking or heating that is placed in
containers for retail sale on or after that date.
List of Subjects in 16 CFR Part 1500
Consumer protection, Hazardous materials, Hazardous substances,
Imports, Infants and children, Labeling, Law Enforcement, Toys.
For the reasons given above, the Commission proposes to amend 16
CFR part 1500 as follows:
PART 1500--HAZARDOUS SUBSTANCES AND ARTICLES; ADMINISTRATION AND
ENFORCEMENT REGULATIONS
1. The authority citation for part 1500 is revised to read as
follows:
Authority: 15 U.S.C. 1261-1278.
2. Section 1500.14 is amended by revising the borderlined label
statement in paragraph (b)(6)(i) and paragraph (b)(6)(ii) as follows:
Sec. 1500.14 Substances requiring special labeling under section 3(b)
of the act.
* * * * *(b) * * *(6) * * *(i) * * *
BILLING CODE 6355-01-P
TP10AU95.114
BILLING CODE 6355-01-C
(ii) For bags of charcoal, the label specified in paragraph
(b)(6)(i) of this section shall appear within a heavy borderline in a
color sharply contrasting to that of the background, on both the front
and back panels in the upper 25 percent of the panels of the bag, at
least 1 inch below the seam and at least 1 inch above any reading
material or design elements. The signal word ``WARNING'' shall be in
capital letters in at least 27-point (7.14 mm, \9/32\ inch) type. The
remaining text of the warning statement shall be in at least 18-point
(4.763 mm, \3/16\ inch) type. The lettering shall have a strokewidth-
to-height ratio of from 1:6 to 1:8, and the spacing between the bottom
of the letters of one line of the statement of consequences and the
statement of how to avoid the hazard and the top of the letter of the
next line of that statement shall be about one-fourth of the height of
the type size. The label shall be at least 50.8 mm (2 inches) high. The
label's lettering and pictogram shall have the size relation to each
other and to the remainder of the label as shown in paragraph (b)(6)(i)
of this section.
* * * * *
Dated: August 1, 1995.
Sadye E. Dunn,
Secretary, Consumer Product Safety Commission.
[[Page 40792]]
Appendix 1--List of Relevant Documents
(Note: This list of relevant documents will not be printed in the
Code of Federal Regulations.)
1. Petition HP 91-1 from Barbara Mauk.
2. Letter to Barbara Mauk from Sadye E. Dunn, CPSC, January 28,
1993.
3. Hampson, N.B. et al., JAMA (January 5, 1994).
4. Cost information from industry.
a. The Clorox Company (Kingsford), P.O. Box 493, Pleasanton, CA
94566.
b. King and Spalding, representing Royal Oak Enterprises, Inc.,
1730 Pennsylvania Ave. N.W., Washington, D.C. 20006.
c. Hickory Specialties, Inc., P.O. Box 1669, Brentwood, TN
37024.
5. Barbecue Industry Association survey. Barbecue Industry
Association, 710 East Ogden, Suite 113, Naperville, IL 60563.
6. Briefing package dated July 6, 1995, with Tabs A-H.
TAB A--Background Information on Charcoal Labeling in Briefing
Package memo dated May 18, 1994 accompanied by FDA's Notices of
Proposed and Final Rulemaking dated September 2, 1970, and August
11, 1971, and Petition for Amending Labeling Requirements for
Charcoal Intended for Household Use, dated October 12, 1990.
TAB B--Memorandum from Laureen E. Burton of Directorate for
Health Sciences to Sharon R. White, entitled ``Carbon Monoxide
Toxicity Review for the Charcoal Labeling Project,'' dated March 8,
1994.
TAB C Memorandum from Leonard Schachter Directorate for
Epidemiology, Division of Hazard Analysis to Sharon R. White,
entitled ``Charcoal Labeling Project,'' dated December 12, 1994.
TAB D--Memorandum from Charles M. Jacobson of Office of
Compliance and Enforcement to Susan E. Womble, entitled ``Compliance
Experience with Current FHSA Labeling Requirements for Charcoal
Briquets,'' dated April 30, 1992.
TAB E--1. Memorandum from Sharon R. White of Directorate for
Engineering Sciences, Division of Human Factors to The File
entitled, ``Proposed Revisions to Labeling Requirements for Packages
of Charcoal'' dated June 15, 1995.
2. Memorandum from George Sweet of Directorate for Engineering
Sciences, Division of Human Factors to Sharon R. White entitled,
``Pictogram Testing for Warning Labels on Charcoal Bags,'' dated
June 12, 1995.
TAB F--Logs of Industry Meetings on (1) April 22, 1994, and (2)
April 13, 1995.
TAB G--Memorandum from Mary F. Donaldson of Directorate of
Economic Analysis to Sharon R. White, entitled ``Economic Analysis
of a Revision to Charcoal Labeling,'' dated June 22, 1995.
TAB H--Draft Federal Register NoticeNotice of Proposed
Rulemaking.
7. Letter from James C. Stephen, President, Weber-Stephen
Products Co., to Sharon R. White, CPSC, May 11, 1995.
8. Letter from Harleigh Ewell, CPSC, to James C. Stephen,
President, Weber-Stephen Products Co., June 29, 1994.
9. Woodson, W.; Tillman, B.; and Tillman, P., 1992.
10. ANSI Z535.3-1991, American National Standard for Criteria
for Safety Symbols.
11. Perry, E., and Neily, M. (1985). Burning Charcoal Briquettes
in a Fireplace. U.S. Consumer Product Safety Commission, Washington,
DC.
12. Letter from Leonard S. Gryn, Executive Vice President,
Weber-Stephen Products Co., to Harleigh Ewell, CPSC, July 5, 1995.
[FR Doc. 95-19357 Filed 8-9-95; 8:45 am]
BILLING CODE 6355-01-P